smoking pipes - Page 2

Water Warrior 2 · 06-22-2012, 05:54 AM

If there is a hole drilled in the air box you better cover it over with duct tape soonest. The air flow is a reverse flow compared to almost everything else out there. You are getting unfiltered air into the engine. Pull out the air filter and you will understand. It gets dirty from the inside first because the air enters from the center and flows out through the filter material.

**jonathan180iq** · 06-22-2012, 08:57 AM

Quote:

Originally Posted by mynameistrey

It does feel a little jerky when i try to cruise at a certain speed, around 25mph is where i feel it the most. Is that carburetor related? Theres also a hole drilled into the top of my air box, could that be the problem?

Not really a problem. It's just unfiltered air being pulled into the engine.....

How large is the hole?

Sounds like some previous owner tried to pull a Honda Civic intake mod on the GZ250 and made a mistake.

mynameistrey · 06-22-2012, 02:20 PM

Quote:

Originally Posted by jonathan180iq

Quote:

Originally Posted by mynameistrey

It does feel a little jerky when i try to cruise at a certain speed, around 25mph is where i feel it the most. Is that carburetor related? Theres also a hole drilled into the top of my air box, could that be the problem?

Not really a problem. It's just unfiltered air being pulled into the engine.....

How large is the hole?

Sounds like some previous owner tried to pull a Honda Civic intake mod on the GZ250 and made a mistake.

Not that big. The width of a nail or screw. I think he was using it to spray carb cleaner through

**jonathan180iq** · 06-22-2012, 03:01 PM

.....that's really interesting.

Where is it located exactly?

mynameistrey · 06-23-2012, 01:50 PM

Quote:

Originally Posted by jonathan180iq

.....that's really interesting.

Where is it located exactly?

alantf · 06-23-2012, 01:58 PM

Well, whatever it is, it shouldn't be there, so you might as well fill it.

mynameistrey · 07-23-2012, 12:47 PM

Hey so I'm back again and have a new problem. I finally got the bike running well, no smoke, no oil leaks while its on. I finally put my first seafoam free tank of gas in it and it's been cruising better at low speeds. My only problem now is when I go to shut it off, it lets off a big puff of white smoke from the engine. Sometimes it goes kind of ghost mode, I turn it off and it turns over 2 more times before cutting off. It looks as though maybe the carburetor might be loose? But it still backfires really loud on shut off. What might cause one big puff of smoke after shutoff?

**jonathan180iq** · 07-23-2012, 01:52 PM

That's called dieseling and it's caused by the engine being way too lean. The chamber is so hot that the excess explosive bits get heated enough to blow up again.

It's an issue that you really need to look into. If you have a carb that isn't fully sealed to the manifold, then that is most likely your problem. Too much air would be getting in causing the whole thing to run way too hot.

mynameistrey · 07-26-2012, 11:41 AM

So it was definitely the carburator. It was just loose. I straightened it back in there and it shuts off easily now. Thanks for the help.

06-22-2012, 05:54 AM	#11
Water Warrior 2 Senior Member Join Date: Dec 2006 Location: Squamish B.C Canada Posts: 11,409	Re: smoking pipes If there is a hole drilled in the air box you better cover it over with duct tape soonest. The air flow is a reverse flow compared to almost everything else out there. You are getting unfiltered air into the engine. Pull out the air filter and you will understand. It gets dirty from the inside first because the air enters from the center and flows out through the filter material. Login or Register to Remove Ads
	0

06-22-2012, 03:01 PM	#14
jonathan180iq Super Moderator Join Date: Jan 2007 Location: Dalton, GA Posts: 3,996	Re: smoking pipes .....that's really interesting. Where is it located exactly?
	0

06-23-2012, 01:58 PM	#16
alantf Senior Member Join Date: Nov 2008 Location: Tenerife (Spain) Posts: 3,718	Re: smoking pipes Well, whatever it is, it shouldn't be there, so you might as well fill it. __________________ By birth an Englishman, by the grace of God a Yorkshireman.
	0

07-23-2012, 12:47 PM	#17
mynameistrey Junior Member Join Date: Jun 2012 Location: jax fl Posts: 9	Re: smoking pipes Hey so I'm back again and have a new problem. I finally got the bike running well, no smoke, no oil leaks while its on. I finally put my first seafoam free tank of gas in it and it's been cruising better at low speeds. My only problem now is when I go to shut it off, it lets off a big puff of white smoke from the engine. Sometimes it goes kind of ghost mode, I turn it off and it turns over 2 more times before cutting off. It looks as though maybe the carburetor might be loose? But it still backfires really loud on shut off. What might cause one big puff of smoke after shutoff?
	0

07-23-2012, 01:52 PM	#18
jonathan180iq Super Moderator Join Date: Jan 2007 Location: Dalton, GA Posts: 3,996	Re: smoking pipes That's called dieseling and it's caused by the engine being way too lean. The chamber is so hot that the excess explosive bits get heated enough to blow up again. It's an issue that you really need to look into. If you have a carb that isn't fully sealed to the manifold, then that is most likely your problem. Too much air would be getting in causing the whole thing to run way too hot.
	1

07-26-2012, 11:41 AM	#19
mynameistrey Junior Member Join Date: Jun 2012 Location: jax fl Posts: 9	Re: smoking pipes So it was definitely the carburator. It was just loose. I straightened it back in there and it shuts off easily now. Thanks for the help.
	0